Respondent operates a granular monoammonium phosphate (GMAP) process and a diammonium phosphate (DAP) process at the Facility, meeting the definition of “process”, as defined by 40 C.F.R. § 68.3. A different Respondent operates an anhydrous ammonia process at the Facility, meeting the definition of “process”, as defined by 40. C.F.R. § 68.3. The GMAP and…...
This is the lens through which we should view EMERGENCY RESPONSE and our local FD as the “primary responders.” Just because we have a local FD (paid full-time or volunteer) does not mean we have the emergency services we need! Far too often, our “assumptions” about the fire service’s capabilities far outstretch their actual abilities…....
Respondent is the owner and operator of the facility. On October 15, 2022, there was an incident at the Facility that resulted in an accidental release of approximately 17,598 pounds of Aluminum Triethyl (ATE). The Incident resulted in an on-site chemical fire at the Facility and a shelter-in-place for the surrounding community. The Respondent’s facility…...
Two people were severely injured after a Nitrogen cylinder catastrophically failed during refilling/pressurization. Person 1 shut off the air and nitrogen gas supplies before yelling to the workshop to call the HSE leader (nurse). Person 2, who was holding the cylinder, suffered severe injuries to his legs and one hand. Person 3 was injured when…...
The investigation has found that the direct cause of the leak was corrosion under the insulation in a 4″ pipe for heavy naphtha from the distillation tower. The lack of inspection and repair meant that the corrosion had continued long enough for a hole to form in the pipe. Piping and equipment in a refinery…...
A safety partnership is defined as: Leadership, managers, and front-line associates jointly focus on safety and proactively work together in a business entity to minimize the possibility of harm and maximize safety performance. (Cooper, 2016) Creating a genuine safety partnership means management and the workforce jointly working towards achieving common and understood safety goals, with…...
On August 6, 2018, at 1:35 pm, an event occurred at Km 4+300 of the road connection between Motorway A1 and Motorway A14 near Bologna (see picture 1 in Annex 1). The section of the road flows over an elevated structure above the urban road network below. Among the vehicles involved in the accidents, there…...
BOYLES LAW: When the temperature is kept constant, the volume of a gas is inversely proportional to the pressure upon it. CHARLES LAW: When the external pressure is kept constant, the volume of a gas is directly proportional to its absolute temperature…. Membership Required You must be a member to access this content.View Membership LevelsAlready...
Every day of the year, billions of cubic feet of gas are stored, transported, and used without any problems or mishaps. This results from a conscientious, solid – effort toward safety within the gas industry. Even with this effort, from time to time, something goes wrong; either mechanical or human error occurs. When this happens,…...
I got this document when I attended a National Fire Academy HAZMAT course in 1993. I came across it when looking for some old HAZMAT material for a new course I am developing and translated and cleaned up some of the language. It does an EXCELLENT job explaining the phenomenon we know as BLEVE (Boiling…...
This picture has caused quite the debate in the SAFTENG circle! Many comments in the SAFTENG LI and FB groups point towards the worker(s), which indicates the belief that this is an “Active Failure” of the worker(s) involved. Many of you would NOT believe the tales I could tell about what I have encountered in…...
OSHA states the following about our non-entry rescue devices… The mechanical device used for emergency rescue must be designed and rated for human use. The standard specifies in paragraph 1910.146(k)(3)(ii) that the retrieval equipment must be designed for personnel. The performance-oriented nature of the standard allows flexibility as to the design specifications of the retrieval…...
